Industrial IDC 810-041 伺服电机

Industrial IDC 810-041 伺服电机

系统功能

4.1、监控报警功能

4.2、控制输出功能

4.3、故障报警功能

• • 被监控设备电源回路开关状态
  • 被监控设备电源的工作状态（电压、电流及报警状态信息）
  • 报警响应时间：≤100s
  • 报警声信号：可手动消除，当再次有报警信号输入时，能再次启动
  • 报警光信号：红色LED指示灯常亮
  • 对个别或全部被监控设备的报警继电器进行远程遥控操作
  • 监控器控制输出：常开无源触点，容量：AC250V 3A或DC30V 3A
  • 监控器与模块（电压/电流信号传感器）之间的连接线断路、短路
  • 监控器主电源欠压（≤80%主电源电压）或过压（≥110%主电源电压）
  • 监控器与其分体电源间连接线断路、短路
  • 当监控器出现以上故障时，能发出与监控报警信号有明显区别的声光故障报警信号
  • 故障报警响应时间：≤100s
  • 故障报警声信号：手动消除，当再次有报警信号输入时，能再次启动
  • 故障报警光信号：黄色LED指示灯常亮
  • 故障期间，非故障回路的正常工作不受影响

    Filter FILTERPATRONE FILTER CARTRIDGE, FILTER, AIR BLOWER/HEATER

    Valve INLINE LOPRO SINGLE STA VALVE

    Valve PTFE AOV VALVE elbow 1/2 FPT

    Sensor 3INS EE-SX674A Sensor

    OEM Part FAN PULLEY SHAFT 6735-03036-0-00

    OEM Part WAFER GUIDE LEFT STC 2x8 PEEK WAFERUEHRUNG LINKS; ABERLE 0715083"

    Motor SMBO SBL3-0250-30-0 SERVO MOTOR

    Motor DRIVE MOTOR LOAD UNLOAD ASSEMBLY

    Sensor Sensor Optical , 50MM, CABLE 3M

    PCB COMMUNICATION BOARD VME

    Cylinder 32x35x20 QUAD ACT HS Pneumatic CYLINDER

    Sensor LIGHT CURTAIN TRANSMITTER OUTPUT SIEMENS 00370067-01

    Electrical Circuit Breaker 6 (C16)

    Valve PNEUMATIC Diaphragm VALVE

    Belt GEARBELT BRECOFLEX, 12T5/2250 SIEMENS 00356841-01

    OEM Part ADVANTEST MKX-D5916-B-1 TC-B Shaft B

    OEM Part PCB Assy Analog I/O

    OEM Part Lower Plate 0.125 in thick, 300mm

    Belt TIMING GEARBELT

    Motor PACIFIC SCIENTIFIC R32GNC-HS-ND-VS Brushless Servo Motor 4000RPM

    Electrical CIRCUIT BREAKER, 400V, 2 POLE, 4AMP

    OEM Part KIT CHAMBER LID H20 RETROFIT

    Sensor 3INS ZC153A SENSOR

    Valve SMC SYJ312-5LOZ-M3 Solenoide Valve

    Filter Hydronix SPC-789-9603 Filter- 1/8 swage in line PKG 3

    OEM Part INTERNATIONAL TEST SOLUTIONS INC PP2031-7003SC PLATE,CREAM,SUB,WPOL,PL

    Motor BRUSHLESS Permanent Magnet SERVOMOTOR, Y-MOTOR S23, 00334154S02, 00334154

    Cable SIEMENS H07V-K 6

    Cable EUPEN H05V-K-K-0 Wire PCV jacket 75 BL RG 50ft

    OEM Part ASSY, PCB, CHAMBER SET INTERCONNECT

    Instrument BLOCK TOP Sight GLASS CELL

    Computer Accessory VGA BOARD SERVICE UNIT

    Sensor AMPLIFIER Fiber Optic

    Encoder Encoder ABSOLUTE HOLLOW SHAFT ENCODER

    Actuator ESEC 13.0165.1 Clamp Wire Solenoid Magnet

    PCB BOM PCB ASSY VISION ADAPTOR CARD

    PCB INTERFACE MODULE, 2287630

    Sensor Amplifier Sensor Optic

    OEM Part AXIS SERVO INTERFACECARD

    OEM Part VARIAN 112410001 FEEDTHROUGH FIL COOLED

    Motor MOTOR TURN OVER (DC+RED) RS220K+GPL-52, PARVEX, RS220KR1000; GYSIN CH-44

    Motor Induction Motor

    Bearing linear slide

    Relay Relay 1 for 1XLC

    Valve Diaphragm Valve Manual , Metal, POS-NR:109

    Filter THERMO SCIENTIFIC FL583X5 1/2 B PURE FILTER 0.45 MIC

    OEM Part PLATE (CARRIER TR.) 25x223x6

    motor Controller SERVO AMPLIFIER TBS/3S1

    Washer PLAIN WASHER M6 ST G.V PKG 6

    Switch GPS 919105-501 ASSY FLOAT SWITCH AQUEOUS,MALE

    Fitting Union PolyPro DA 25 PKG 4

    OEM Part Speedline Technologies 1005933 DAM, DUAL DURO ASSY PKG 6

    Hardware Nowpak dispense head Photo resist Smart Probe

    Sensor OMRON DCB-EP5680X03B optical sensor

    Sensor SENSOR Fiber optic no amplifier

    Power Supply POWER SUPPLY 50W 12-15V

    Bearing BEARING, LINEAR W120 W44 H30 B32 J36

    Valve SAFETY VALVE PRV (SPINDLE COOLANT) 22221

    Hardware MARTIN PD80-1002 Dosing pen 5ccm for EB/PD/CD/SD-02

    Filter Filter 0.05u Teflon

    Flowmeter FLOWMETER, 807 PP, 0,6-6,4 m3/h DN 50

    motor Controller CARD SMD 70V (STEP MOTOR SHOW, ELT 92/70-36, 2004644, 980818-89

    Sensor PHOTO MICROSENSOR

    O-Ring GREEN TWEED 9108-SC520 Chemraz O-Ring0.237ID X 0.102CX IN PKG 13

    Belt Belt Timing belt 16T10 2210-V endless

    Hardware CRIMP AMP TINNED LOOSE, 170365-1 PKG 100

    Regulator Regulated Valve Manifold EV210B

    OEM Part BELLOWS FINGER LIFT, HASTALLOY PRODUCER

    Switch VACUUM SENSOR-Switch Adjustable

    PCB VME CPU Lynix 2.3 MVME 147

    Switch OMRON E3T-ST12 Photoelectric Switch 12 to 24V DC

    Thermo Couple (TC) TEMPERATURE MEASUREMENT PROBE

    Wafer NOVELLUS 94-2730 WAFER ASSEMBLY,A2000 JIG

    Valve Throttle valve

    Motor MAXON A-MAX 240176 MOTOR with GEARHEAD ASSEMBLY 110451

    Heater HEATER CARTRIDGE, HLP 200V 280W 9805

    OEM Part NOVELLUS 15-054583-00 CLIP,RETAINING,MOER HOLDER PKG 7

    MFC UNIT MFC 8565 50SCCM NH3 Downport-C MTL N/C HOV DNET 4R AMAT 3030-11791

    PCB FORCE COMPUTER 880-12536-101 LAM RESEARCH (LAM) 810-017035-001 PCB SASI CON

    Spring 3INS CH3- Spring

    Thermo Couple (TC) THERMOMETER RESISTANCE shielded h124-x

    OEM Part COVER (WATER-PROOF)

    PCB PCB W COMP YASKAWA INTERFACE

    Actuator Pneumatic Actuator 10x160 DOUBLE-acting M5, DIAM/STROKE: 10/160, 10/03

    Valve SOLENOID FOR TYPE 2610 VALVE Body 240V AC-DC BURKERT 0243-3224-118-00

    Valve TEFLON valve body

    Valve VALVE Speed Control

    Filter Pall filter Posidyne N66 2L 0.04

    Cylinder Pneumatic Cylinder lift

    Controller ESEC 110.0737.1FLOW CONTROLER, 1/500

    Tool SOLDAPULT SS 350 De-soldering Tool

    Electrical YAMAICHI 60FBGA-NP367-MV TEST SOCKET ADAPTER SCRAMBLE BOARD 512M D11

    Filter Filter141200186 DESTILLO2 DEIONIZING 30D CARTRIDGE, DISPOSABLE CARTRIDGE

    Connector CENTRONICS 740314-77 Kabelsrecker 50-POL (2 PKG)

    Sensor PHOTOELECTRIC SENSOR N507-152704, 10bar, U- 10-30VDC, J-200mA

    Motor Motor M6771 Z-DRIVE-MOTOR 108V/400W, MQMA042C421, VRKF-5C-400-Z, NIDEC-SH

    MFC MYKROLIS FC-2979MEP5 MASS FLOW CONTROLLER; MILLIPORE TYLAN 2979M SERIES MASS

    Sensor PRESSURE SENSOR / TRANSDUCER

    Sensor PHD 53603-1-02 Hall effect sensor

    OEM Part ADAPTOR, ISO/THROTTLE CLUSTER 200MM PROD